94 Golf Project, 90% Complete - 7,000
Posted by mack73
Jason Wine Ultra Moderator Location: Seattle, WA Join Date: 02/20/2006 Age: Midlife Crisis Posts: 448 Rally Car: Started a Golf... Never Finished It |
Time to let the build go. Started when I had more time than money, then life happened. After getting married, buying a house and having a kid. I now have more money than time… but rather than letting this sit for years, I would love to see someone else finish it and get it out to a rally.
The car is ~ 90% complete. Mockup was done and is need of final assembly and minor finishing. Specs: - 94 VW Golf 4 door. No Sunroof - Roll Cage by Dave Clark - NASA Log Book, inspected by Gene - Fully seam welded. Front subframe mounts replaced with threaded steel inserts through the frame in double shear (you won’t rip those suckers out). All undercoating stripped - ABF 2.0 16v European engine. I was told it only has 15k on it since a rebuild. I didn’t tear it down to confirm, but from looking at the valvetrain and cross hatch in the cylinder bores I believe it. - 02A tranny rebuilt by Robert Gobright. 4.24 R&P with a spool. Converted to hydraulic clutch and cable shifter. Shift tower moved inside the vehicle to be closer to the wheel. - Tranny mount welded to frame rail - Burmeister Strut Mounts - Plan was to go with Carbs. So twin side draft 47mm OER carbs (Japanese webber copies) with ITG filter. - Electromotive XDI crank trigger ignition system. (No injection, so carbs only) - All wiring is done (minus hookups at rally lights as they were never installed) and running 12v to the fuel pump from relay. Engine wiring harness was stripped of all extras and ECU. Factory harness now runs lights, starter. All additional electrical circuits run on a separate fuse block and relays mounted to passenger side dash. - Full Autometer gauges. - Brantz International 2 rally computer wired to VSS signal from Tranny - Sabelt seats. Ferrari challenge for driver, Taurus for passenger - Roof vent - ATL fuel cell recessed into trunk floor. - All fuel lines (braided) are run inside. Dual Carter fuel pumps routed in parallel - 11” Corrado G60 front brakes (still 4 lug, requires 15” wheels) - Hydraulic hand brake with proportioning valve. All brake hard lines run inside. New master cylinder. - 2:1 steering quickener, Momo steering wheel with hub - Fire suppression system (will need a re-charge) - Battery mounted inside with 150 amp circuit breaker on ground. - Have new clutch, pressure plate, flywheel, wheel bearings, tie rod ends, A-arms, Rear main seal and probably a lot more parts I forgot about - Had the crazy idea to run independent suspension in the rear. Built mounts to use a front subframe in the rear. But due to an aftermarket component on 1 side, vs OEM on the other, the mounts were welded in 1/8” to the passenger side. I was going to move the mounts over, but you can always go back to stock as the OEM rear suspensions mounts are still there and the stock beam will be included. - Also includes a spare stock 8v ABA and another 02A tranny. Both would require a rebuild. Left to do: - Install Engine/Tranny - Underbody Protection (Engine skid plate, HDPE) - Build Exhaust from cat to outside of car - Missing body parts: Windshield and front bumper - Fuel Cell cover (or whatever ridiculous box over a box over a box is required now) - Build mount for rally lights (if you want them) - Replace consumable (Brake rotors/pads, flexible brake lines, spark plugs, etc) - Need rally suspension, belts, spill kit, emergency kit $7,000. Really want to sell this as a package, but if I can’t find a buyer I will part it out. Tons of pictures available to send.  -Jason |
Wilson von Kessler Senior Moderator Location: Lookout Mountain, GA Join Date: 02/28/2006 Age: Possibly Wise Posts: 1,127 Rally Car: Colts are in Finland; now '87 325i, '89 325i |
Robert Gobright Infallible Moderator Location: White Center Seattle Join Date: 04/27/2008 Age: Possibly Wise Posts: 1,292 Rally Car: 91 VW GTI 8V |
Jason Wine Ultra Moderator Location: Seattle, WA Join Date: 02/20/2006 Age: Midlife Crisis Posts: 448 Rally Car: Started a Golf... Never Finished It |
Not trying to pull one over on anyone or make back my money - a stack (I never let the wife see) has over 20k in receipts........... But if someone thinks its too high, shoot me a price. here are some more pics from various stages over the years 
 -Jason |
Wilson von Kessler Senior Moderator Location: Lookout Mountain, GA Join Date: 02/28/2006 Age: Possibly Wise Posts: 1,127 Rally Car: Colts are in Finland; now '87 325i, '89 325i |
PIERCE FABIAN Super Moderator Location: Vancouver, BC Join Date: 02/19/2015 Age: Midlife Crisis Posts: 46 Rally Car: '96 Jetta |
Josh Wimpey Mega Moderator Location: VA Join Date: 12/27/2006 Age: Midlife Crisis Posts: 649 Rally Car: Sneak the Golf |
Jason Wine Ultra Moderator Location: Seattle, WA Join Date: 02/20/2006 Age: Midlife Crisis Posts: 448 Rally Car: Started a Golf... Never Finished It |
Haha its true... ah well to be young and foolish.... stock beam included  But you will need to stiffen it up using the VW motorsports idea to triangulate the 'arms'-Jason |
Chris Krepski Elite Moderator Location: Gatineau, Québec Join Date: 02/25/2010 Age: Possibly Wise Posts: 31 Rally Car: 1991 VW Golf, 8V of fury! |
Dave Cotie Mod Moderator Location: North Bay, ON Canada Join Date: 03/27/2007 Age: Possibly Wise Posts: 125 |
Jason Wine Ultra Moderator Location: Seattle, WA Join Date: 02/20/2006 Age: Midlife Crisis Posts: 448 Rally Car: Started a Golf... Never Finished It |
Jason Wine Ultra Moderator Location: Seattle, WA Join Date: 02/20/2006 Age: Midlife Crisis Posts: 448 Rally Car: Started a Golf... Never Finished It |
John Vanlandingham Ultra Moderator Location: Ford Asylum, Sleezattle, WA Join Date: 12/20/2005 Age: Fossilized Posts: 14,152 Rally Car: Saab 96 V4 |
Dave Cotie Mod Moderator Location: North Bay, ON Canada Join Date: 03/27/2007 Age: Possibly Wise Posts: 125 |
James Riley Godlike Moderator Location: Flagstaff, AZ Join Date: 01/29/2013 Age: Possibly Wise Posts: 11 Rally Car: 2002 WRX |
Sorry, only registered users may post in this forum.